POLYESTER SPRAY FILLER 1KG
|
|
Product:
127.978
|
Revision Date:
2018/09/04
|
|
|
|
|
Product name:
|
|
Manufacturer emergency phone number:
|
|
Supplier:
|
CarWorx Distribution Inc.
3800 Transcanada Hwy
Pointe-Claire, Quebec, Canada
H9R 1B1
|
|
Chemical family:
|
|
Product uses:
|
|
TDG classification:
|
RESIN SOLUTION
UN1866
Class 3
PG III
|
|
|
|
Special instructions:
|
|
DSL status:
|
The substance(s) listed in the ingredients section appear on the Domestic Substances List
|
|
Information phone number:
|
514-745-5959 (1-877-745-5959)
|
|
Synonyms:
|
|
Date of the supplier's latest SDS revision:
|
|
Recommended restrictions on use:
|
For use in industrial installations or professional treatment only
|
|
|
|
C.A.S. |
CONCENTRATION % |
Ingredient Name |
T.L.V. |
LD/50 |
LC/50 |
100-42-5 |
10-25 |
STYRENE
|
20 PPM |
2650 MG/KG
RAT ORAL
316 MG/KG
MOUSE ORAL
|
11800 MG/M3/4H
RAT INHALATION
9500 MG/M3/4H
MOUSE INHALATION
21000 MG/M3/2H
MOUSE INHALATION
|
| |
|
Supplier's LD50 and LC50 values:
|
CAS# 100-42-5: LD50 > 2000 mg/kg rat dermal
|
|
|
|
Melting point (°C):
|
|
Physical state:
|
|
Appearance & odor:
|
Grey
|
Characteristic odour
|
Fluid
|
|
Odor threshold (ppm):
|
|
pH:
|
|
Specific gravity @ 20 °C:
|
|
Initial boiling point/Boiling range (°C):
|
|
Vapour pressure (mmHg):
|
|
Vapour density (air=1):
|
|
Freezing point (°C):
|
|
Evaporation rate
(butyl acetate = 1):
|
|
By weight:
|
|
Solubility in water (%):
|
Not miscible or difficult to mix
|
|
Coefficient of water\oil dist.:
|
|
VOC:
|
|
Solid content:
|
|
Density:
|
|
Relative density:
|
|
|
|
Flammability:
|
|
Conditions of flammability:
|
Heat, sparks and open flames
|
|
Extinguishing media:
|
Carbon dioxide
|
Water spray
|
Powder
|
Do not use direct water jet
|
For large fires use water spray
|
|
Special procedures:
|
Firefighters should wear adequate protective gear
|
Positive pressure self-contained breathing apparatus required and full protection to prevent skin
contact
|
Use water spray to cool fire exposed containers
|
Collect contaminated fire fighting water separately. It must not enter the sewage system
|
Dispose of fire debris and contaminated fire fighting water in accordance with official regulations
|
|
Flash point (°C), method:
|
|
Auto-ignition temperature (°C):
|
|
Upper flammability
limit (% vol):
|
|
Lower flammability
limit (% vol):
|
|
Hazardous combustion products:
|
Formation of toxic gases is possible during heating or in case of fire
|
|
Sensitivity to static discharge:
|
|
Sensitivity to mechanical impact:
|
|
Rate of burning:
|
|
Explosive power:
|
|
Lower explosive limit:
|
|
Upper explosive limit:
|
|
|
|
Chemical stability:
|
Product is stable under normal handling and storage conditions
|
|
Conditions of instability:
|
Heat, sparks & open flame
|
All ignition sources
|
Direct sunlight
|
|
Hazardous polymerization:
|
|
Incompatible substances:
|
Peroxides
|
Other radical components
|
|
Hazardous decomposition products:
|
|
|
|
Route of entry:
|
Skin contact, eye contact, inhalation and ingestion
|
|
Eye contact:
|
Causes serious eye irritation
|
|
Skin contact:
|
|
Skin absorption:
|
|
Inhalation:
|
May cause respiratory irritation
|
|
Ingestion:
|
|
Effects of chronic exposure:
|
Causes damage to the hearing organs through prolonged or repeated exposure
|
|
LD50 of product, species & route:
|
Not available for mixture, see the ingredients section
|
|
LC50 of product, species & route:
|
Not available for mixture, see the ingredients section
|
|
Exposure limit of material:
|
Not available for mixture, see the ingredients section
|
|
Sensitization to product:
|
May cause skin sensitization on prolonged contact
|
|
Carcinogenic effects:
|
|
Reproductive effects:
|
Suspected of damaging the unborn child
|
|
Teratogenicity:
|
|
Mutagenicity:
|
|
Synergistic materials:
|
|
|
|
Gloves/Type:
|
Fluorocarbon rubber
|
Do not use PVC gloves
|
Do not use nitrile gloves
|
Do not use natural rubber gloves
|
Do not use butyl rubber
|
|
Respiratory/Type:
|
|
Approved air purifying respirator for vapors
|
|
|
In case of brief exposure or low pollution use respiratory filter device
|
|
|
Eye/Type:
|
Tight fitting safety goggles
|
|
|
Footwear/Type:
|
Safety shoes per local regulations
|
|
Clothing/Type:
|
Wear adequate protective clothes
|
|
Other/Type:
|
Eye wash facility should be in close proximity
|
Emergency shower should be in close proximity
|
|
Ventilation requirements:
|
Local exhaust and/or general ventilation
|
To maintain exposure below TLV
|
|
Leak/Spill:
|
Eliminate all sources of heat and ignition
|
Evacuate all non-essential personnel
|
Prevent entry into drains, sewers, and other waterways
|
Avoid all personal contact
|
Wear appropriate protective equipment
|
Do not flush area with water
|
Place in appropriate container for disposal
|
Absorb with liquid-binding material (sand, diatomite, acid binders, universal binders, sawdust)
|
Prevent the formation of vapor/air mixtures
|
|
Waste disposal:
|
Do not dispose in sewers
|
Do not dispose of with normal garbage
|
|
Handling procedures and equipment:
|
Keep away from heat, sparks, and open flame
|
Use adequate ventilation
|
Wash thoroughly after using, particularly before eating or smoking
|
Equipment must be grounded to prevent static sparks
|
Avoid smoking in area of use
|
Avoid contact with skin, eyes and clothing
|
Do not eat, drink or smoke in handling area
|
|
Storage requirements:
|
Keep away from heat, sparks, and open flames
|
Avoid static electricity - ground containers when transferring product
|
Keep out of direct sunlight
|
Store below 30°C
|
Store away from oxidizing materials
|
Store in original container
|
Store in a cool, dry and well ventilated area
|
Store away from food
|
Store in tightly sealed containers
|
|
Special shipping information:
|
See transportation information
|
|
|
|
Skin contact:
|
Wash thoroughly with soap and water
|
If irritation occurs, consult a physician
|
|
Eye contact:
|
Immediately flush with copious amount of water. Get medical attention
|
|
Inhalation:
|
Remove victim to fresh air. If not breathing, qualified personnel should administer artificial
respiration. Get medical attention
|
Keep person warm and at rest
|
|
Ingestion:
|
Obtain immediate medical attention
|
Do not induce vomiting
|
Never give anything by mouth to an unconscious person
|
|
Additional information:
|
The above information is believed to be correct but does not purport to be all inclusive and shall
be used only as a guide. This company shall not be held liable for any inaccuracies
|
|
Note to physician:
|
|
|
|
Issued by:
|
Environment, health and safety
|
|
Data prepared by:
|
Conform-Action Data Systems
A division of 2843471 Canada Inc.
wwww.netmsds.com
Tel: (514) 683-2060
E-mail: Support@cads.ca .
|
|
|